Aprilaire Duct Sealing Nationwide

Aprilaire Duct Sealing in Fort Lauderdale: What to Know First

Aprilaire duct sealing in Fort Lauderdale typically costs between $850 and $2,400 depending on how much of your duct run needs work, and most jobs are finished in a single day. We’re an independent Aprilaire service provider, not a factory-authorized shop, so we make parts and pricing decisions based on what actually serves your home, not what a corporate program dictates. If you own an Aprilaire system and your ducts are leaking conditioned air, this page explains what’s failing, what it costs to fix, and how we work. For a written quote, call (754) 354-3644.

Call (754) 354-3644

How Aprilaire Products Fail – and How We Fix Them

Aprilaire is known for air purification, humidifiers, and filtration. But a lot of Fort Lauderdale homes also run Aprilaire ductwork and dehumidifier tie-ins, and those components fail in predictable ways after years of salt air and humidity. Here’s what we see most.

• Aprilaire E100 and E130 dehumidifier duct connections pulling loose at the collar. These units cycle often in Fort Lauderdale because humidity stays high eleven months a year. Every cycle flexes the duct connection. After a few years, the collar loosens and conditioned air leaks into the attic. We remove the old collar, reseal with duct mastic, and refasten so the connection holds through the constant on-off cycling.
• Aprilaire 5000 electronic air cleaner housing cracks around the duct flange. This is the one we see most on homes near the Intracoastal. Salt-laden air corrodes thin metal at the flange, and the unit’s own weight opens a gap over time. We pull the housing, seal or replace the flange, and remount it flush. This is a repair OEM guidance doesn’t address well, because the failure mode is South Florida specific, not common in drier climates.
• Flex duct runs connected to Aprilaire zone dampers sagging and separating. Zone systems like the Aprilaire 6504 rely on dampers that open and close throughout the day. Each cycle pushes and pulls the flex duct. Over time, the takeoff separates from the trunk line, right at the zip tie or foil tape. We find this in attics across Victoria Park and Coral Ridge. Our fix is the same one we’d use on a Lennox or Trane job: strip the failed connection, reseat the duct, and seal with mastic, not tape.
• Condensation rot at Aprilaire filter cabinet seams. The Aprilaire 2200 and 4200 filter cabinets sit in the airstream and sweat in Fort Lauderdale’s humidity. The seams were sealed at the factory, but ten years of moisture wicks into the sealant and breaks it down. You’ll see rust streaks or water staining below the cabinet. We clean the seam, apply fresh mastic rated for continuous moisture contact, and confirm the drain path is clear.
• Aprilaire fresh-air intake duct pulling away from the soffit vent. Homes built after about 2015 often have an Aprilaire 8126 ventilation control running a fresh-air duct to the soffit. The duct gets pulled when the roofers or pest-control crews work in the soffit space, and it stays disconnected for years because nobody looks. We find this on inspection calls in Plantation and Davie regularly. A disconnected fresh-air duct means your ventilation system is pulling attic air, not outside air, and the fix is simple: refit the takeoff and reseal it properly.

Our Aprilaire Duct Sealing Process

Every Aprilaire job runs the same way, and the price is written before we touch anything.

1. 1
   Call and describe the issue. We schedule a visit inside a quoted window. You get a live person on the phone, not a callback queue.
2. 2
   Walkthrough and diagnostic. Roy or one of our techs inspects the Aprilaire unit, the duct connections, and the runs. We look for loose collars, failed tape, moisture evidence, and any spots where attic air is getting pulled into closed work. We also check filter condition, because a clogged Aprilaire media filter changes static pressure enough to mask a duct leak.
3. 3
   Written quote before work starts. We show you the number, explain what’s included, and that number does not move. No per-vent add-ons, no upgrade pitch mid-job.
4. 4
   The sealing work. We use duct mastic and foil-backed tape on accessible runs, and we’re clear about what’s reachable without cutting drywall. We also inspect and reseal the Aprilaire unit’s own connections to the plenum, because that’s where a surprising number of leaks live.
5. 5
   Verification. We run the blower and feel the repaired joints. If we find a remaining leak, we address it right then, not later.
6. 6
   Cleanup and guarantee. We leave the space cleaner than we found it and hand you a written summary showing what was sealed and where. Every repair is covered by our 365-Day Done Right Promise. If the work fails within a year, we come back and make it right at no charge.

What Aprilaire Duct Sealing Costs in Fort Lauderdale

Most Aprilaire duct sealing jobs we do in Fort Lauderdale land between $850 and $2,400. Here’s how that breaks down.

• Single-point Aprilaire repair (one collar, one damper connection, one flange): $180 to $400. This is the most common call.
• Resealing the Aprilaire unit to the plenum plus accessible supply returns: $800 to $1,400. This covers the unit-to-duct interfaces and up to 8 to 10 accessible joints.
• Whole-system duct sealing on a single-story Fort Lauderdale home, including Aprilaire filter cabinet, dehumidifier tie-in, and zone dampers: $1,600 to $2,400 depending on attic access and how many runs we can reach.

What moves the price: attic accessibility, how many Aprilaire components are tied into the duct system, and whether we’re repairing one joint or sealing every accessible seam. Every quote is written before work starts, and it does not change. Call (754) 354-3644 for a free estimate, and we’ll tell you the number for your system before we schedule anything.

Why Fort Lauderdale Homeowners Call Hollis Air Duct Fort Lauderdale for Aprilaire Work

We’ve been doing this since 2004 under The Garrison Standard, and that standard is not a suggestion. It means we arrive inside the window, price in writing, do the job by the book, and leave the site clean. The 365-Day Done Right Promise is printed on your paperwork: if our duct seal fails within a year, we come back at no charge, including a free second visit. Our techs are background-checked and uniformed, and they know Aprilaire equipment well enough to tell you when a repair makes sense and when a part is too far gone to save. On the same property, we also service Lennox, Trane, and Carrier systems, so if your air handler is leaking at the coil cabinet while we’re in the attic, we can address that too. Roy Castellanos and his crew have sealed Aprilaire ductwork in homes a few blocks from Las Olas Boulevard and in commercial buildings near the Port Everglades corridor. Salt air and humidity push every system down here, and we’ve been fixing the fallout for the better part of two decades. Clean ducts move air. Everything else is just noise.

FAQs